Res. Agr. Eng., 2015, 61(4):150-161 | DOI: 10.17221/45/2013-RAE
Thermal and physical properties modelling of terebinth fruit (Pistacia atlantica L.) under solar dryingOriginal Paper
- 1 Department of Biosystems Engineering, Faculty of Agriculture, Bu-Ali Sina University, Hamedan, Iran
- 2 Departments of Horticultural Sciences, Faculty of Agriculture, Bu-Ali Sina University, Hamedan, Iran
A laboratory solar dryer was used to study terebinth fruit drying. Two solar collectors were adjusted in east-west directions with the angle of 45°. Initial moisture content of terebinth fruit was dried under natural and forced airflow. In order to predict terebinth moisture content during drying process five mathematical models were used. Colour change and shrinkage of the terebinth samples were calculated. Results showed that the Page model had the best performance in moisture content prediction of terebinth samples. Effective moisture diffusivity of terebinth fruit was increased under forced convection. The lowest colour change and shrinkage of the samples in natural air flow condition were observed. Maximum rupture force and energy values were obtained at maximum airflow velocity. Models were fitted to the experimental data of physical, thermal and mechanical properties of terebinth fruit with high correlation coefficients.
Keywords: thin layer; moisture diffusivity; shrinkage; colour; rupture energy
Published: December 31, 2015 Show citation
References
- Abbasi Souraki B., Mowla D. (2008): Axial and radial moisture diffusivity in cylindrical fresh green beans in a fluidized bed dryer with energy carrier: modeling with and without shrinkage. Journal of Food Engineering, 88: 9-19.
Go to original source...
- AOAC (2000): Official methods of analysis of the AOAC. Association of Official Analysis Chemists. Washington DC, USA.
- Aghbashlo M., Kianmehr M.H., Hassan-Beygi S.R. (2009): Drying and rehydration characteristics of sour cherry (Prunuscerasus L.). Journal of Food Processing and Preservation, 34: 351-365.
Go to original source...
- Aktas M., Ceylan I., Yilmaz S. (2009): Determination of drying characteristics of apples in a heat pump and solar dryer. Desalination, 239: 266-275.
Go to original source...
- Altuntas E., Gercekcioglu R., Kaya C. (2010): Selected mechanical and geometric properties of different almond cultivars. International Journal of Food Properties, 13: 282-292.
Go to original source...
- Amiri Chayjan R., Salari K., Abedi Q., Sabziparvar A.A. (2013): Modeling of moisture diffusivity, activation energy and specific energy consumption of squash seeds in a semi fluidized and fluidized bed drying. Journal of Food Science and Technology, 50: 667-677.
Go to original source...
Go to PubMed...
- Arevalo-Pinedo A., Murr F.E.X., Arevalo Z.D.S., GiraldoZuniga A.D., (2010): Modeling with shrinkage during the vacuum drying of carrot (Daucuscarota). Journal of Food Processing and Preservation, 34(S2): 611-621.
Go to original source...
- Arslan D., Ozcan M.M. (2010): Study the effect of sun, oven and microwave drying on quality of onion slices. LWTFood Science and Technology, 43: 1121-1127.
Go to original source...
- Arumuganthan T., Manikantan M.R., Rai R.D., Anandakumar S., Khare V. (2009): Mathematical modeling of drying kinetics of milky mushroom in a fluidized bed dryer. International Agrophysics, 23: 1-7.
- Brasiello A., Adiletta G., Russo P., Crescitelli S., Albanese D., Di Matteo M. (2013): Mathematical modeling of eggplant drying: shrinkage effect. Journal of Food Engineering, 114: 99-105.
Go to original source...
- Cakmak G., Yildiz C. (2011): The drying kinetics of seeded grape in solar dryer with PCM-based solar integrated collector. Food and Bioproduct Processing, 89: 103-108.
Go to original source...
- Chowdhury M.M.I., Bala B.K., Haquem A. (2011): Energy and exergy analysis of the solar drying of jackfruit leather. Biosystems Engineering, 110: 222-229.
Go to original source...
- Cihan A., Kahveci K., Hacihafizoglu O. (2007): Modeling of intermittent drying of thin layer rough rice. Journal of Food Engineering, 79: 293-298.
Go to original source...
- Dash A.K., Pradhan R.C., Das L.M., Naik S.N. (2008): Some physical properties of simarouba fruit and kernel. International Agrophysics, 22: 111-116.
- Demir V., Gunhan T., Yagcioglu A.K. (2007): Mathematical modeling of convection drying of green table olives. Biosystems Engineering, 98: 47-53.
Go to original source...
- Desmorieux H., Madiouli J., Herraud C., Mouaziz H. (2010): Effects of size and form of Arthrospira spirulina biomass on the shrinkage and porosity during drying. Journal of Food Engineering, 100: 585-595.
Go to original source...
- Doymaz I. (2004): Pretreatment effect on sun drying of mulberry fruits (Morus alba L.). Journal of Food Engineering, 65: 205-209.
Go to original source...
- Doymaz I. (2005): Sun drying of figs: an experimental study. Journal of Food Engineering, 71: 403-407.
Go to original source...
- Garcia-Segovia P., Mognetti C., Andres-Bello A., MartinezMonzo J. (2010): Osmotic dehydration of Aloe vera (Aloe barbadensis Miller). Journal of Food Engineering, 97: 154-160.
Go to original source...
- Ghanem N., Mihoubi D., Kechaou N., Mihobi N.B. (2012): Microwave dehydration of three citrus peel cultivars: Effect on water and oil retention capacities, color, shrinkage and total phenols content. Industrial Crops and Products, 40: 167-177.
Go to original source...
- Gharibzahedi S.M.T., Mousavi S.M., Hamedi M., Khodaiyan F., 2012. Comparative analysis of new Persian walnut cultivars: nut/kernel geometrical, gravimetrical, frictional and mechanical attributes and kernel chemical composition. Scientia Horticulturae (ISHS), 135: 202-209.
Go to original source...
- Hashemi G., Mowla D., Kazemeini M. (2009): Moisture diffusivity and shrinkage of broad beans during bulk drying in an inert medium fluidized bed dryer assisted by dielectric heating. Journal of Food Engineering, 92: 331-338.
Go to original source...
- Hertog A.T.M., Ben-Arie R., Roth E., Nicola B.M. (2004): Humidity and temperature effects on invasive and noninvasive firmness measures. Postharvest Biology and Technology, 33: 79-91.
Go to original source...
- Hii C.L., Law C.L., Cloke M., Suzannah S. (2009): Thin layer drying kinetics of cocoa and dried product quality. Biosystems Engineering, 102: 153-161.
Go to original source...
- Hossain M.A., Bala B.K. (2007): Drying of hot chilli using solar tunnel drier. Solar Energy, 81: 85-92.
Go to original source...
- Janjai S., Mahayothee B., Lamlert N., Bala B.K., Precoppe M., Nagle M., Muller J. (2010): Diffusivity, shrinkage and simulated drying of litchi fruit (Litchi chinensis Sonn.). Journal of Food Engineering, 96: 214-221.
Go to original source...
- Janjai S., Precoppe M., Lamlert N., Mahayothee B., Bala B.K., Nagle M., Muller J. (2011): Thin-layer drying of litchi (Litchi chinensis Sonn.). Food and Bioproduct Processing, 89: 194-201.
Go to original source...
- Janjai S., Lamlert N., Intawee P., Mahayothee B., Bala B.K., Nagle M., Muller J. (2009): Experimental and simulated performance of a PV-ventilated solar greenhouse dryer for drying of peeled longan and banana. Solar Energy, 83: 1550-1565.
Go to original source...
- Johnston J.W., Hewett E.W., Hertog A.T.M. (2002): Postharvest softening of apple (Malus domestica) fruit: a review. Crop and Horticultural Science, 30: 145-160.
Go to original source...
- Kaya A., Aydin O., Demirtas C. (2007): Drying kinetics of red delicious apple. Biosystems Engineering, 96: 517-524.
Go to original source...
- Kingsly A.R.P., Meena H.R., Jain R.K., Singh D.B. (2007): Shrinkage of ber (Zizyphus mauritian L.) fruits during sun drying. Journal of Food Engineering, 79: 6-10.
Go to original source...
- Kituu G.M., Shitanda D., Kanali C.L., Mailutha J.T., Njoroge C.K., Wainaina J.K., Silayo V.K. (2010): Thin layer drying model for simulating the drying of Tilapia fish (Oreochromis niloticus) in a solar tunnel dryer. Journal of Food Engineering, 98: 325-331.
Go to original source...
- Koc B., Eren I., Ertekin F.K. (2008): Modelling bulk density, porosity and shrinkage of quince during drying: the effect of drying method. Journal of Food Engineering, 85: 340-349.
Go to original source...
- Kurosawa L.E., Hubinger M.D., Park K.J. (2012): Glass transition phenomenon on shrinkage of papaya during convective drying. Journal of Food Engineering, 108: 43-50.
Go to original source...
- Manuwa S.I., Muhammad H.A. (2011): Effects of moisture content and compression axis on mechanical properties of Shea kernel. Journal of Food Engineering, 105: 144-148.
Go to original source...
- Mercier S., Villeneuve S., Mondor M., Des Marchais L.P. (2011): Evolution of porosity, shrinkage and density of pasta fortified with pea protein concentrate during drying. LWT-Food Science and Technology, 44: 883-890.
Go to original source...
- Mohsenin N.N. (1996): Physical characteristics: Physical Properties of Plant and Animal Materials. New York, Gordon and Breach Science Publisher.
- Nazari Galedar M., Mohtasebi S.S., Tabatabaeefar A., Jafari A., Fadaei H. (2009): Mechanical behavior of pistachio nut and its kernel under compression loading. Journal of Food Engineering, 95: 499-504.
Go to original source...
- Odjo S., Malumba P., Dossou J., Janas S., Bera F. (2012): Influence of drying and hydrothermal treatment of corn on the denaturation of salt-soluble proteins and color parameters. Journal of Food Engineering, 109: 561-570.
Go to original source...
- Phungamngoen C., Chiewchan N., Devahastin S. (2013): Effects of various pretreatments and drying methods on Salmonella resistance and physical properties of cabbage. Journal of Food Engineering, 115: 237-244.
Go to original source...
- Pott I., Neidhart S., Muhlbauer W., Carle R. (2005): Quality improvement of non-sulphited mango slices by drying at high temperatures. Innovative of Food Science and Emerging Technology, 6: 412-419.
Go to original source...
- Prachayawarakorn S., Sawangduanpen S., Saynampheung S., Poolpatarachewin T., Soponronnarit S., Nathakakule A. (2004): Kinetics of colour change during storage of dried garlic slices as affected by relative humidity and temperature. Journal of Food Engineering, 62: 1-7.
Go to original source...
- Sacilik K., Keskin R., Elicin A.K. (2006): Mathematical modelling of solar tunnel drying of thin layer organic tomato. Journal of Food Engineering, 73: 231-238.
Go to original source...
- Singh K.P., Mishra H.N., Saha S. (2010): Moisture-dependent properties of barnyard millet grain and kernel. Journal of Food Engineering, 96: 598-606.
Go to original source...
- Sirisomboon P., Kitchaiya P., Pholpho T., Mahuttanyavanitch W. (2007): Physical and mechanical properties of Jatropha curcas L. Fruits, nuts and kernels. Biosystems Engineering, 97: 201-207.
Go to original source...
- Tripathy P.P., Kumar S. (2009): A methodology for determination of temperature dependent mass transfer coefficients from drying kinetics: Application to solar drying. Journal of Food Engineering, 90: 212-218.
Go to original source...
- Usub T., Lertsatitthankorn C., Poomsa-Ad N., Wiset L., Siriamornpun S., Soponronnarit S. (2010): Thin layer solar drying characteristics of silkworm pupae. Food and Bioproduct Processing, 88: 149-160.
Go to original source...
- Vega-Galvez A., Miranda M., Diaz L.P., Lopez L., Rodriguez K., Di Scala K. (2010): Effective moisture diffusivity determination and mathematical modeling of the drying curves of the olive-waste cake. Bioresource Technology, 101: 7265-7270.
Go to original source...
Go to PubMed...
- Vega-Galvez A., Uribe E., Perez M., Tabilo-Munizaga G., Vergara J., Garcia-Segovia P., Lara E., Di Scala K. (2011): Effect of high hydrostatic pressure pretreatment on drying kinetics, antioxidant activity, firmness and microstructure of Aloe vera (Aloe barbadensis Miller) gel. LWT-Food Science and Technology, 44: 384-391.
Go to original source...
- Wakabayashi K. (2000): Minireview: changes in cell wall polysaccharides during fruit ripening. Journal of Plant Research, 113: 231-237.
Go to original source...
- Yadollahinia A., Latifi A., Mahdavi R. (2009): New method for determination of potato slice shrinkage during drying. Computers and Electronics in Agriculture, 65: 268-274.
Go to original source...
- Zheng C., Sun D.W., Zheng L. (2006): Correlating color to moisture content of large cooked beef joints by computer vision. Journal of Food Engineering, 77: 858-863.
Go to original source...
- Zielinska M., Markowski M. (2010): Air drying characteristics and moisture diffusivity of carrots. Chemical Engineering and Processing: Process Intensification, 49: 212-218.
Go to original source...
This is an open access article distributed under the terms of the Creative Commons Attribution-NonCommercial 4.0 International (CC BY NC 4.0), which permits non-comercial use, distribution, and reproduction in any medium, provided the original publication is properly cited. No use, distribution or reproduction is permitted which does not comply with these terms.